Curlex blankets shall be trenched at the head of the slope if the blanket cannot be extended three feet over the slope crest or if overland flow is anticipated from upslope areas. Channels: Curlex blankets shall be centered to offset a seam in the middle of the waterway. They shall be installed in the same direction as the water flow.
What is curlex blanket?
Curlex is the original erosion control blanket. It is engineered specifically with Great Lakes Aspen curled wood fibers which promote ideal growing conditions for grass seed, while also protecting the topsoil from erosion. The multi-directional Curlex fiber matrix is bound by photo-degradable, biodegradable, or permanent netting.
What is an Erosion Control Blanket?
An erosion control blanket is a blanket of synthetic or natural fibers to protect soil from the erosive impact of rain and water flow, typically on slopes and in channels. Erosion can be the result of rainfall, wind and severe weather.
What is curlex fiber matrix?
The multi-directional Curlex fiber matrix is bound by photo-degradable, biodegradable, or permanent netting. Typical applications include highway embankments, ditch bottoms and slopes, urban drainage, and much more!
What is a Curlex blanket?
How to install Excelsior blankets?
What are Aspen blankets made of?
What kind of blankets did Millstone Bangert use?
What is the fiber length of a Great Lakes Aspen blanket?
How long does it take for a blanket to break down?
How high should a blanket be installed?
See 2 more
What is Curlex used for?
Curlex is the original erosion control blanket. It is engineered specifically with Great Lakes Aspen curled wood fibers which promote ideal growing conditions for grass seed, while also protecting the topsoil from erosion.
How do you use an erosion control blanket?
Seed, fertilize, and compact the soil. Place the top of the blanket in the trench, ensuring the blanket reaches about one foot beyond the edge. Use landscaping staples to secure the erosion control blanket to the bottom of the trench, then do the same on the excess 18 inches past the edge.
Where does the erosion control blanket go?
Use a shovel, tiller, aerator, or pitchfork to break compacted soil once you have cleared the site (if necessary). It is important for the erosion control blanket to lie directly on the topsoil without any obstructions. You will need to dig a shallow trench at the top if installing on a slope or a hill. Remove 1/2 ft.
What are straw blankets used for?
Like jute netting, straw blankets are designed for slope erosion protection and vegetation establishment. They are used to hold soil in place and promote the growth of new vegetation on all types of slopes, i.e. landfill slopes, drainage slopes, road slopes, and backyard slopes.
Do you remove erosion control blanket?
The netting is supposed to stay in the ground until it disintegrates, and there is no practical reason to remove the netting at any point in the process. Taking it up only increases the likelihood that everything you put in the ground will blow away – defeating the purpose.
Can you mow over Curlex?
It is color-coded white to identify it as a rapid break-down, polypropylene netting designed for use in areas to be mowed.
How do you lay Curlex?
Curlex blankets shall be centered to offset a seam in the middle of the waterway. They shall be installed in the same direction as the water flow. The adjoining blankets shall be installed away from the center of channel and concentrated water flow. They shall be secured by a common row of staples.
How long does it take for straw blanket to decompose?
6 months to 2 yearsStraw Blankets biodegrade over shorter periods of time (typically 6 months to 2 years). They are designed for low slopes and limited water flow with overall moderate conditions.
Can you seed under erosion blanket?
To prevent this loss of seed, you can cover the new planting area with an erosion mat, sometimes also called an erosion blanket. These mats hold the seeds in place until they germinate but are porous enough to allow the seeds to grow through them.
Can you just sprinkle grass seed on lawn?
Can you just sprinkle grass seed on top of your existing lawn? While it's possible to simply sow the new grass seed over your existing lawn, taking the time to prepare your lawn beforehand will increase the likelihood of seed germination and improve your end result.
How do you install straw erosion control blanket?
1:575:45How to Install a Rolled Erosion Product - YouTubeYouTubeStart of suggested clipEnd of suggested clipGoing. Step four lay out the product in the trench with the roll sitting up slope of the excavation.MoreGoing. Step four lay out the product in the trench with the roll sitting up slope of the excavation. You want to make sure that you roll out enough so that it goes all the way into your trench.
How do you use a seed blanket?
0:027:56Using Germination Blankets to Grow Grass Seed on a Hill - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt's actually really easy to unroll. You just got to take your time at the beginning part here whereMoreIt's actually really easy to unroll. You just got to take your time at the beginning part here where you can see it's caught up and then I figure out oh that's part of the next layer.
How long does it take for straw blanket to decompose?
6 months to 2 yearsStraw Blankets biodegrade over shorter periods of time (typically 6 months to 2 years). They are designed for low slopes and limited water flow with overall moderate conditions.
How does a grass seed blanket work?
Germination blankets allow light and water to reach seeds underneath them so they will sprout. Blankets also warm the soil to germinate seeds more quickly. Seeds may be washed away by heavy rains, but seed blankets hold the seeds in place so they do not wash into one spot, sprout in clumps and leave other areas bare.
Can you seed under erosion blanket?
To prevent this loss of seed, you can cover the new planting area with an erosion mat, sometimes also called an erosion blanket. These mats hold the seeds in place until they germinate but are porous enough to allow the seeds to grow through them.
Can you seed over erosion blanket?
“When erosion is not a big factor, and it's the right time of the year, we can overseed, put seed in the ground, and not just on the top. Not a big slope? No blanket. And we seed separately-no seeded blankets, because all projects are different; some are temporary seed, and some are permanent.”
What is a Curlex blanket?
Curlex is the original erosion control blanket. It is engineered specifically with Great Lakes Aspen curled wood fibers which promote ideal growing conditions for grass seed, while also protecting the topsoil from erosion. The multi-directional Curlex fiber matrix is bound by photo-degradable, biodegradable, or permanent netting.
How to install Excelsior blankets?
The only exception is with waterway slopes. The blankets should be centered to offset the seam in the middle of the waterway. The blankets should be installed in the same direction as the flow of water while the adjoining blankets should be installed away from the center channel and concentrated water flow. They should be secured with a row of common staples . It's not normally necessary to overlap the blankets, but a 2-inch shingle-type installation can be used in the application of waterway slopes.
What are Aspen blankets made of?
These blankets are made with exclusive soft barbed interlocking curled Aspen excelsior fibers and are free of any weed seeds. You can get these blankets for a variety of environments sensitivities or you get a stronger netting for job sites with more difficult requirements.
What kind of blankets did Millstone Bangert use?
Millstone Bangert, Inc decided to go with Curlex I QuickGRASS erosion control blankets instead of sod. Once the paving and grading were completed, the green blankets were installed on the project. The blankets were secured with 11-gauge steel wire staples along the pavement edge. By that time, the weather had turned hot and dry but the native fescue and perennial rye seeds were able to get enough moisture to germinate and the seedlings were established. Once the blanket started to fade, it was replaced with natural green vegetation!
What is the fiber length of a Great Lakes Aspen blanket?
This is a very carefully cut of Great Lakes Aspen curled wood excelsior with 80% six-inch fibers or greater fiber length. It comes with a consistent thickness along with fibers evenly distributed throughout the entire blanket. The top of the blanket is covered with photodegradable or biodegradable netting and will be free of all weed seeds or chemical additives.
How long does it take for a blanket to break down?
The netting is plastic that is degradable based off of UV exposure, oxygen, heat, and soil conditions. Most blankets start to breakdown at 90 days.
How high should a blanket be installed?
Our blanket installation should continue up the side slopes, 3-feet above the anticipated high water elevation. Flanks that are exposed to sheet flow or runoffs must be protected by a trench or check slot. The blankets should be trenched at the starting point of the channel and anchored using a staggered staple pattern at the end of the roll overlaps and end of the roll terminations.
What is Curlex Netfree?
Our latest innovation is Curlex NetFree - The first erosion control blanket (ECB) that doesnot use any netting material.
Does Curlex Netfree contain weed seed?
Fibers in Curlex NetFree shall be evenly distributed over its entire area and 80% of the fibers shall be six inches orlonger with consistent thickness. Biodegradable stitching shall be used to form the continuous matrix of Curlex fibers.Curlex NetFree erosion control blankets do not contain any chemical additives, weed seed, or foreign matter.
What is an erosion control blanket?
An erosion control blanket is a blanket of synthetic or natural fibers to protect soil from the erosive impact of rain and water flow, typically on slopes and in channels. Erosion can be the result of rainfall, wind and severe weather.
How wide is a retaining wall erosion control blanket?
Most of these are rolled up and cut into widths ranging from 3 to 8 feet wide. Erosion control blankets are a good solution to use on steep slopes, above ditches, beside driveways and on construction sites. They can be used with or without a retaining wall as part of your system.
What is erosion fabric?
Erosion fabrics come in two forms: woven netting with open spaces, and blankets of continuous fibers attached to mesh. The mesh material may be natural or synthetic, and some synthetic mesh may be photodegradable. Fibers may be stitched to one mesh layer or sandwiched between two. Continuous fiber blankets cover the soil surface completely, ...
Why should native vegetation be installed with erosion control fabrics?
Native vegetation should be installed with erosion control fabrics because the blankets only address surface erosion and most are designed to break down over time. Native plants have an extensive and varied root system that will prevent both surface and subsurface erosion for the long term.
What is a synthetic geotextile?
Synthetic geotextiles are more frequently used as part of a permanent stabilization structure, such as soil lifts. Synthetic weed barriers often require removal, which can disrupt native plant establishment. Jute Netting. Made from the natural fiber jute, this netting is used as an erosion control device alone or used to hold together other erosion ...
How long do blankets last?
These blankets are made with agricultural straw and a biodegradable net that are sewn together. If the blanket should last for up to one year, there are thicker options made with the same material, or wood shavings and natural fibers. Extended length blankets are intended to protect an area for up to 2 years. These are made to be more substantial and combine materials like straw, coconut fibers, polypropylene nets and UV stabilized thread. Permanent blanket options are also known as turf reinforcement mats. These are made strong enough to withstand tougher conditions on slopes, coastlines, river banks and high-flow channels.
What is a continuous fiber blanket?
Continuous fiber blankets cover the soil surface completely, and are usually used on steeper sites or in drainage channels.
What is a Curlex blanket?
Curlex is the original erosion control blanket. It is engineered specifically with Great Lakes Aspen curled wood fibers which promote ideal growing conditions for grass seed, while also protecting the topsoil from erosion. The multi-directional Curlex fiber matrix is bound by photo-degradable, biodegradable, or permanent netting.
How to install Excelsior blankets?
The only exception is with waterway slopes. The blankets should be centered to offset the seam in the middle of the waterway. The blankets should be installed in the same direction as the flow of water while the adjoining blankets should be installed away from the center channel and concentrated water flow. They should be secured with a row of common staples . It's not normally necessary to overlap the blankets, but a 2-inch shingle-type installation can be used in the application of waterway slopes.
What are Aspen blankets made of?
These blankets are made with exclusive soft barbed interlocking curled Aspen excelsior fibers and are free of any weed seeds. You can get these blankets for a variety of environments sensitivities or you get a stronger netting for job sites with more difficult requirements.
What kind of blankets did Millstone Bangert use?
Millstone Bangert, Inc decided to go with Curlex I QuickGRASS erosion control blankets instead of sod. Once the paving and grading were completed, the green blankets were installed on the project. The blankets were secured with 11-gauge steel wire staples along the pavement edge. By that time, the weather had turned hot and dry but the native fescue and perennial rye seeds were able to get enough moisture to germinate and the seedlings were established. Once the blanket started to fade, it was replaced with natural green vegetation!
What is the fiber length of a Great Lakes Aspen blanket?
This is a very carefully cut of Great Lakes Aspen curled wood excelsior with 80% six-inch fibers or greater fiber length. It comes with a consistent thickness along with fibers evenly distributed throughout the entire blanket. The top of the blanket is covered with photodegradable or biodegradable netting and will be free of all weed seeds or chemical additives.
How long does it take for a blanket to break down?
The netting is plastic that is degradable based off of UV exposure, oxygen, heat, and soil conditions. Most blankets start to breakdown at 90 days.
How high should a blanket be installed?
Our blanket installation should continue up the side slopes, 3-feet above the anticipated high water elevation. Flanks that are exposed to sheet flow or runoffs must be protected by a trench or check slot. The blankets should be trenched at the starting point of the channel and anchored using a staggered staple pattern at the end of the roll overlaps and end of the roll terminations.
